Delkor DC 31 100 A/H Marine Deep Cycle & Storage Battery

IF OUT OF STOCK, USE ROYAL (Delkor Rebranded) DC31 BATTERY, CLICK ON BUTTON BELOW TO LINK OVER TO Royal DC31 BATTERY PAGE:

CLICK HERE TO LINK TO ROYAL DC 31 battery PAGE IF OUT OF STOCK

12 Volts

100 A/H

Semi Sealed Maintenance Free

• Calcium maintenance free dual purpose battery
• Heavy Duty "Deep Cycle" Wrought lead-calcium grids
• Low-Resistance envelope separators
• High strength polypropylene case
• Heat Sealed covers
• Exclusive patented liquid gas separator
• Built in Hygrometer
• Dual Terminal (SAE Post & 1150K Wing Nut)
• Ruggedized Heavy Duty Case
• High CCA Rating

PLEASE NOTE:

The Delkor DC31 is a 12V 100Ah DEEP CYCLE BATTERY

WE RECCOMEND USING THE DC31 (de-coded - Deep Cycle - Group 31 Case Size Marine Deep Cycle Battery) in Domestic Home Inverter Systems!

The Life Expectancy is 250 Cycles from whatever State Of Charge at Beginning of Discharge to 80 % Depth of Discharge!

MANUFACTURER'S WARRANTY IS:

a) 12 Months / 250 Cycles in Marine Vessel or Leisure Vehicle

b) 6 Months / 250 Cycles / Loadsheddings (Whichever comes first) in Load Shedding Inverter Application.

BATTERY LIFE EXPECTATION

The DC31 battery has a 1 year manufacturer’s warranty (carry-in owing to normal use) / 200-250 Cycles @ 80 % Depth of Discharge in Leisure / Marine Use.

The DC31 battery has a 6 month manufacturer’s warranty (carry-in owing to normal use) / 200-250 Cycles / Loadsheddings in Inverter / Standby / UPS Use.

This translates roughly to 200-300 Loadsheddings of 2.5 - 4 Hours Duration (Dependent on load) or 4 - 5 Years Life on Float Charge (Whichever comes first)

Failure to allow sufficient Recharge Time between Loadshedding Events to achieve at least 90 % State of Charge results in ABNORMAL WEAR AND TEAR  due to the battery continuously and repetitively operating in the lower band of State of Charge. An analogy would be operating the Pneumatic Tyres on your car at low pressure (Voltage is "Electrical Pressure")

Fully Discharged Batteries take +- 8 – 16 Hours to fully recharge at the recommended charge rate of 10 % of Capacity. (+-10A Charge on a Wet Cell Calcium Deep Cycle Battery)

We highly recommend that you size your battery accordingly to achieve 4+ hours runtime to Full Discharge (10.5 Volts) Two DC31 Batteries will run 350 Watts of Load for FOUR Hours before reaching the Low State Of Charge Cut Off Voltage.

This results in a Discharge of approximately 50% on a 350 Watt Load after the end of each 2 Hour Loadshedding event, and, at some time during a 24 Hr period, an extended  "rest period" of 10 hours during which the battery can fully Charge to 100 %.

During Eskom Stages 1 - 4 the average loadshedding is 2 hours, this means that the battery will be discharged to +-50% during these Stages 1 - 4, leaving 5 hours charge time (about 50 Ah) to reach "Near Full State of Charge" between Load Shedding events, and, at some time during a 24 Hr period, an extended "rest period" of 10 hours during which the battery can fully Charge to 100 %. (This "Rest Period):

During Periods of Sustained Stage 5 and higher Load Shedding Events we would suggest reducing loads to bare minimum items needed / turning the inverter output off if not in use / Increasing battery capacity to 4 X batteries and charging current to 20A per battery.

NB: THE 1150K BATTERY (and all 102Ah / 105Ah Batteries) ARE NOT "DEEP CYCLE BATTERIES

(1150 K Decoded means 1150 Cranking Amps at Standard Atmospheric Temperature and Pressure)

WE RECCOMEND USING THE DC31 (de-coded - Deep Cycle - Group 31 Case Size Marine Deep Cycle Battery) in Domestic Home Inverter Systems!

Batteries failing due to deep discharges and not being allowed to FULLY recharge between loadsheddings will result in battery failures which are not covered by the manufacturer’s warranty.

Batteries take +- 8 – 16 Hours to fully recharge. (+-10A Charge)

We highly recommend that you size your battery accordingly to make 8 hours runtime
This will mean the battery will be at 50% state of charge at the end of a loadshedding.

We strongly recommend that non-essential items are turned off during loadshedding.

Batteries with reduced runtimes indicate that the battery is reaching / reached it's end of cycle life and should be replaced

General life in standby use during occasional stage 1 - 2 loadshedding: 1 - 3 Years

Design Life: 3 - 5 Years (In standby use, kept on charge, not discharged)

We strongly recommend that non-essential items are turned off during periods of intense loadshedding. Also, Switch off items like the TV set or your computer when sleeping or absent from home, if possible, place the Inverter Charger in "Rest Mode" (Charge, but Do Not Invert) if absent from home or sleeping. Common Sense Prevails!

Batteries with reduced runtimes indicate that the battery is reaching / or is about to reach it's end of cycle life and you should plan a battery replacement